高配比磁铁精粉制粒和烧结性能优化
CSTR:
作者:
作者单位:

作者简介:

周 卫 (1979—),男,高级工程师,从事烧结工艺和智能控制方面的研究工作。

通讯作者:

中图分类号:

TF046.4

基金项目:

国家自然科学基金青年科学基金资助项目 (52004339)


Optimization of granulation and sintering performance of high-ratio magnet concentrate
Author:
Affiliation:

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    针对某内陆型钢厂进行高比例磁铁精矿(混匀矿中占比≥85%)烧结时出现的制粒效果差、烧结矿产、质量低和固体燃料消耗高等问题,为确定下一步工程技改方向,本文开展系统的烧结杯试验以揭示高配比磁铁精粉的烧结特性,探究精矿预润湿、生石灰用量、磁铁精粉配比、碱度、料层高度等因素对烧结性能及成品矿冶金性能的影响规律。结果表明:采用精矿预润湿技术和配加适量生石灰对于协同强化高配比铁精矿制粒具有促进作用,在相同制粒水分条件下,将混合铁精矿初始水分 3.0% 预润湿至 7.8%,同时配加 5.5% 生石灰,制粒所得混合料的透气性指数 (JPU) 由 14.1 大幅提高到 41.7;在混合料透气性得到保证的前提下,进一步提高碱度和料层厚度能显著改善烧结矿产、质量指标,且烧结矿各冶金性能指标均能满足高炉冶炼要求。本文研究成果将为现场技术改造和生产提供重要的理论依据和技术指导。

    Abstract:

    In view of such problems as poor granulation effect, low quality of sintering ores and high solid fuel consumption when sintering a high-ratio magnetite concentrate (85% of mixed ore) in an inland steel mill, in order to determine the direction of the next engineering technological transformation, a systematic laboratory sintering cup test is carried out to reveal the sintering characteristics of high-ratio magnet concentrate, and to explore the influence rule of such factors as concentrate pre-wetting,quicklime dosage, magnet concentrate ratio, alkalinity, and material layer height on the sintering performance and metallurgical performance of the finished ore. The results show that the pre-wetting technology of concentrate and the addition of an appropriate amount of quicklime can promote the high-ratio iron concentrate granulation of synergistic strengthening, under the same granulation moisture conditions, the initial moisture of the mixed iron concentrate is pre-wetted from 3.0% to 7.8%, and 5.5% quicklime is added at the same time, and the air permeability index (JPU) of the granulated mixture is greatly increased from 14.1 to 41.7. On the premise that the air permeability of the mixture is guaranteed, further increasing the alkalinity and layer height can significantly improve the specification of sintering ores, and the metallurgical performance indexes of sinter can meet the requirements of blast furnace smelting. The results will provide important theoretical basis and technical guidance for on-site technical transformation and production.

    参考文献
    相似文献
    引证文献
引用本文

周 卫,朱德庆,杨聪聪,潘 建,王 欣.高配比磁铁精粉制粒和烧结性能优化[J].烧结球团,2024,(1):56-64

复制
分享
相关视频

文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:
  • 最后修改日期:2023-01-08
  • 录用日期:
  • 在线发布日期: 2026-08-20
  • 出版日期:
文章二维码